Building a human civilization on Mars will be orders of magnitude harder than any of the human migrations on Earth ever were. Here, you can build refuge anywhere, which is why our civilization is everywhere from pole to pole.
If we ever hope to live on the red planet, we must build with the red dirt right beneath our boots, a challenge that has long been thought to demand expensive, huge industrial machinery and nuclear plant-level power generation. Now, a team of researchers has unveiled a radical, low-energy alternative in which a crew could carry a tiny tube of dormant yeast from Earth, breed trillions of helper cells in a vat using Martian carbon dioxide and melted ground ice, and 3D print entire outposts using modest solar power.
The new approach, led by Jishen Qiu at the Hong Kong University of Science and Technology and detailed in a study published in Chem Circularity, uses the freezing Martian climate to its advantage. Instead of melting rock, the team created what they call a “Martian living building material” by blending sand with a water-based binder made of pig-derived gelatin and genetically modified yeast. When extruded and exposed to simulated Martian surface conditions—temperatures averaging minus 85 degrees Fahrenheit and an atmosphere roughly a hundred times thinner than Earth’s—the material freezes and dehydrates on its own.
The physical results are competitive with conventional construction products. The composite achieves an average compressive strength of about 12 megapascals, placing it alongside standard lightweight concrete, while its flexural strength—how well a material resists snapping under bending pressure—reaches 6 megapascals.
That high flexural strength means the material resists bending and tension twice as well as typical lightweight concrete, a critical trait for surviving high-velocity debris hurled by Martian sandstorms. At the same time, producing 1 cubic meter (35 cubic feet) of the biocomposite demands tens of times less material processing energy than sintering, or baking mineral grains together with intense heat, running on less than an hour of standard solar power rather than days of continuous heating.
This solution is not without challenges and roadblocks, but it beats the alternatives so far. The leading blueprints for Martian construction have relied on brute force. Most proposals center on sintering, a technique that blasts loose Martian regolith—the powdery soil and broken rock covering the planet’s surface—with lasers, microwaves, or giant solar kilns to melt it into ceramic blocks. The drawback is severe: Melting rock requires temperatures exceeding 1,800 degrees Fahrenheit. Powering that kind of heat demands nuclear reactors or massive solar arrays running for weeks just to produce enough material for a basic outpost. The resulting ceramic is brittle, cracks easily under bending loads, and cannot be recycled once damaged. It’s extremely hard to do.
Other options include going underground or into mountains like Tolkien dwarves. These are also extremely expensive, requiring huge machinery and energy bills. That could be the way to go for the far future but—at least for the first waves of colonists—we need a lighter and more affordable solution.
Genetic Engineering Is the Key
The secret behind the material’s strength lies in genetic modification—turning ordinary baker’s yeast into living, microscopic construction workers. Natural yeast cells are simple, smooth spheres, but Qiu’s team modified their DNA to sprout three distinct tools on their outer skins.
First, they added AGA2, a surface protein that acts like an anchor to tether the cells directly to sand grains. Second, they engineered the cells to produce mussel foot proteins—synthetic replicas of the supersticky glue sea mussels use to grip wave-battered rocks underwater. Third, they added a paired protein system called SpyTag and SpyCatcher; like microscopic Velcro, the two parts snap together the instant they touch, forming permanent chemical bonds that lock neighboring yeast cells together into an unbroken web.
When that paste exits a 3D printer nozzle heated to a warm 98.6 degrees Fahrenheit—normal human body temperature—it hits the bitter cold of Mars. Normally, freezing water expands into large, dagger-like ice crystals that would tear the material apart. Instead, the protein coats on the yeast act as microscopic traffic cops, forcing the ice to freeze into an orderly grid of tiny, 5-micrometer pockets.
Because the Martian atmosphere is a razor-thin quasi vacuum, that ice never melts; it sublimates, evaporating directly from solid ice into gas. Once the moisture vanishes into thin air, it leaves behind a lightweight, sponge-like skeleton of animal gelatin, with the embedded yeast acting like steel rods inside concrete slabs to keep the walls from collapsing.
As a bonus, this is all recyclable. The researchers tested the cured bricks to the breaking point by crushing them under heavy hydraulic presses. But then they didn’t throw out the rubble. They gently warmed the debris back into a spreadable paste and 3D printed brand-new structural blocks through four consecutive generations. The recycled bricks suffered zero loss in compressive strength or stiffness, and the internal yeast cells emerged alive and kicking every single time.
Solvable Roadblocks
Despite the laboratory success, taking this technology out of the environmental chamber and onto the Martian surface presents hurdles that Qiu acknowledges need to be solved. The most immediate technical limitation is that the highest-performing formula still relies on porcine gelatin imported from Earth, he tells me in an email interview. To achieve true independence, the yeast must synthesize the entire structural scaffold on its own, cutting out animal products entirely.
When I asked Qiu why the yeast cannot yet replace pig gelatin, he explained that the issue isn’t whether the biological glue holds up. The glue sticks, but the cells do not yet churn out enough physical volume of protein to form the shock-absorbing lattice needed to distribute structural loads evenly across the sand.
Water management poses another operational dilemma. Because the bricks harden through open-air freeze-drying, moisture sublimates directly into the thin Martian atmosphere—a daunting trade-off in a world where every liter of water is vital for drinking and rocket propellant. To prevent that loss, Qiu suggests that the entire printing and curing process could move inside a lightweight air dome so the evaporated water can be trapped and recycled—though he doesn’t view water consumption as a dealbreaker, since vast reserves of surface ice are available in several regions of Mars.
Then there are the thorny issues of biology and planetary law. Because the engineered yeast survives the freeze-drying process fully viable, unleashing it on Mars directly bumps up against the planetary protection mandates of NASA and the international Committee on Space Research that are designed to keep alien environments free of terrestrial biological contamination.
The reality is that, once we put boots up there, the mandates are going out the hatch. The day living astronauts step out of a lander, trillions of skin and gut microbes arrive with them, making construction yeast just one piece of a much larger containment puzzle. As Qiu points out, “as long as human beings landed, there would be a good chance that the microbes in our body may be exposed to the atmosphere there.”
The final roadblock to using organic material to create Martian habitats is the brutal bath of unshielded cosmic radiation sweeping the red landscape. Prolonged radiation could mutate or destroy organisms, and Qiu acknowledges that they haven’t tested yet for the resistance of the yeast. Yet he is confident that synthetic biology already has an answer waiting in nature. “We are sure that some microbes can do it and can also be genetically engineered for similar purposes, like making mechanical proteins,” he says.
A lot has to happen between these experiments and actual colonization—like the spaceships to take us there, everything is still a sci-fi fantasy—but the research ultimately demonstrates that off-world construction does not have to rely on heavy industrial kilns. By substituting massive thermal energy with programmable cellular biology, future explorers might construct permanent shelters from little more than dirt, ice, and a tube of living organisms.